1994-1997 Power Stroke Technical Info [Archive] - PowerStrokeNation : Ford Powerstroke Diesel Forum

1994-1997 Power Stroke Technical Info


  1. 2nd IDM failure in 2 years
  2. Does my powerstroke sound abnormally loud or am I being paranoid?
  3. 96 7.3 ran fine, parked last night, now no start, no wts light, no tach when cranking.
  4. Truck stumbles and dies at idle but starts again
  5. blue smoke no power low fuel pressure
  6. 7.3 Hot Start Issue
  7. Removing stuck glow plug on 96 7.3
  8. 1996 7.3L ZF-5 idle RPM
  9. 97 OBS 7.3 E4OD to 4R100 conversion
  10. Sounds like a miss
  11. Trans Overheating
  12. 3.55 or 4.10s
  13. Mixing Coolant Types?
  14. Rear blocks removal
  15. 1995 f350 check engine light
  16. 97 F350 will not go above idle no power?
  17. Cooler install on 97 obs
  18. Ndash to monitor gauges
  19. In the meantime...
  20. 1996 F350 intermediate brake cable
  21. Whats this plug?
  22. AIH issue
  23. These old ones blow
  24. IDM Connector
  25. Missfire low power
  26. 4x4 swap questions
  27. 97 severe valve recession
  28. 97 f250 throttle
  29. 1995 7.3 NO START HELP!
  30. Harmonic balancer problems
  31. rear end vibration 97 f350
  32. P1395 again
  33. Miss / No power / Major Vibration
  34. ZF S5-47 & BW 4407 bolt up torque spec?
  35. F-SUPERDUTY master cylinder
  36. Driver side fuel head leak 7.3 97
  37. 97 F350 Frame Repair
  38. Maxi Fuse #13 Under Hood
  39. 1997 F250 Cooler confusion (pics)
  40. HPOP install
  41. '03 7.3l into a '97
  42. PCM reflash for split shot injectors in OBS non Cali
  43. Motorcraft GL360 215 amp Alternator Trouble
  44. E4OD Rebuild Help
  45. E4OD TC lockup
  46. Simple fix for fuel tank filler vent problem
  47. Bad fuel sensor in tank
  48. Oil filter talk...
  49. Pain in the A**
  50. Fuel pressure
  51. Yo
  52. HPOP question
  53. Torque Pro/OBDLinkMX
  54. Starts. Dies. Won't start.
  55. Question Concerning OBD
  56. Oil Leak Question
  57. Issues with my 95 7.3 dump truck
  58. Still on the hunt for a radius arm
  59. 1995 F-350 Parking Brake Issues
  60. 7.3 needs pump from gas pedal to start.. why?
  61. Front end replacement 2wd. Anything to watch out for
  62. 1997 F-250 de-fueling?
  63. 95 7.3 HPOP & reservoir questions before deciding on new pump
  64. post #2 1995 powerstroke will turn over, won,t start
  65. Who know what setup this is?
  66. 95 7.3 powerstroke turn over won,t start
  67. 1997 7.3 towing
  68. 1/2" Wheel Spacer and Alcoas
  69. Part number or name?
  70. Another OBS 1997 7.3 dying abruptly.
  71. Radius arm what's interchangeable
  72. 1996 Axle Swap Leaf Spring brackets.
  73. LIMPING LIKE A 3 LEGGED DOG
  74. 2wd to 4wd parts cost
  75. Slight miss on acceleration
  76. 97 f250 been sitting for 3 years
  77. Transmission solutions for a "heavy duty" f350
  78. IDM or what?????
  79. Questions About E40D Transmission Issues and normal life span.
  80. 1996 low oil pressure
  81. Negative camber issue
  82. 95 running a month ago died help
  83. 1996 7.3 just a question
  84. 1996 f250 ujoints???
  85. WTS light - symptom or cause?
  86. AC system rebuild
  87. Sending unit wiring diagram?
  88. Fuel Gauge Issues
  89. CCSB ZF5 4x4 driveshaft length
  90. 95 f-350 with 7.3 completely stumped
  91. 7.3 rough idle/P0282 code
  92. Changing signal input of EBP sensor?
  93. 1997 F250HD fuel problem
  94. Powersteering flush
  95. Fuel pressure readings
  96. Supercab drip rails/gutter cross section
  97. Electrical fun
  98. Alternator SOS
  99. Slight miss , sometimes...
  100. Torque pro map reading
  101. R and R Front Cover
  102. 97 7.3 f350 DRW - dual tanks - fuel filler necks/tubes
  103. 5th Wheel Towing Question
  104. Advice? Looking at a '97 7.3L Powerstroke
  105. 96 7.3 powerstroke rpm chime?
  106. Coolant and oil smell in cab
  107. Zf5 swap
  108. Baro Sensor
  109. ICP torque spec
  110. Overdrive will not work! 97 F350 Auto 7.3 Diesel
  111. 7.3L F250 Difficulty starting
  112. runs rough (sometimes)
  113. ICP question
  114. Differential question
  115. "best" mechanical fuel pump
  116. Engine stalls when in gear with acceleration
  117. New 95 owner problems
  118. 1996 f350 powerstroke cclb no start
  119. Rough idle with check engine light
  120. A/C has no power.
  121. 97 F-350 ZF-5 Shifter Tunnel Hump
  122. Grinding/Clunking when shifting into park.
  123. OBS 7.3 “stutter” issue
  124. Up-Pipe Upper Bolts and Turbo Pics
  125. Egt’s and intercooler
  126. E-brake on driveshaft f350 drw
  127. 95 Powerstroke?
  128. Rough idle,tach,tranny
  129. OBD Connection/What are others?
  130. F350 Front Spring Options
  131. 97 ps 198k
  132. intermittent no start no smoke issue.
  133. Real world towing?
  134. GREMLIN HUNTING
  135. 97 not cranking!
  136. door hinges for OBS
  137. Headlight issues
  138. Hi all!! Quite a head scratcher
  139. OBS ZF5 weird vibration issue
  140. Balance fault?
  141. Pinion bearings. What bore size?!
  142. pitman arm/steering box
  143. Starting issues, 1995 7.3
  144. Diesel Bronco Front Suspension Question
  145. 97 f250 no start (IPR not changing)
  146. Getting to the Door hinge bolts
  147. VinBiesel. Ever have one of those electrical problems?
  148. speed sensor??
  149. 95f250 7.🌲
  150. difference between EBP sensors
  151. Decreased power
  152. Truck shaking badly
  153. 95 powerstroke no power and white smoke
  154. hard acceleration/ power issues
  155. Scan Tool
  156. 97 E350 Van, no WTS light, blowing 30 amp fuses on ignition, suspecting fuel bowl heater...
  157. Trouble Codes
  158. 97 No Start
  159. Grinding/dry bearing noise 2wd when hubs locked
  160. Oil cooler orings
  161. Valley drain hole
  162. Rear Hub is wearing a beveled edge!
  163. Back at it with hard starts!
  164. Massive oil leak
  165. 42 pin connector
  166. Frame interchange questions
  167. door actuator pergatory
  168. 96 7.3 With Dana 60 intermittent squeaking in front left wheel.
  169. 96 7.3 Oil leak from the middle of the drivers side oil rail back.
  170. 7.3 low loping on start up
  171. 7.3 NO power, rough idle sounds like it's missing
  172. ebpv not closing all the way
  173. Front door hinge replacement/repair
  174. 1992 idi to 1996 psd conversion
  175. Manifolds
  176. Door locks locking/unlocking randomly
  177. Please help going crazy
  178. Loss of fuel
  179. Peak EOT?
  180. 97 f350 7.3
  181. Oil bypass valve
  182. Need help with some problems with my turn signals and hazards
  183. Fuel tank reading issues
  184. Power steering hose (pump to box) upgrade?
  185. 05+ coil swap
  186. ZF5 flywheel inspection cover
  187. Disk Brake Conversion
  188. P1272 high to low open on #2
  189. Just got a 97
  190. P1272 whats most likely
  191. Stock Lug Nuts Alcoa
  192. Vibration when idling In gear
  193. Need suggestions please
  194. Thinking of buying low mileage 7.3, does this price seem CRAZY!?
  195. Do I Need A New Tq Converter?
  196. Zf5 question
  197. Alternator.
  198. 1997 f250 7.3l with e4od
  199. 7.3 using alot of oil, compression test decent
  200. 97 ford f250hd 7.3 e40d
  201. Water Pump recommendations
  202. better glow plugs for 96 7.3 powerstroke
  203. Calling all tow pros... Gauges, MPG's, possible upgrades?
  204. Stalling after disconnecting batteries.
  205. What is this part?
  206. 7.3 Rough Idle
  207. e-fuel controller addition
  208. OBS Water Pump Fun
  209. 1995 f350 brake slowly falling to floor
  210. Installed new tranny, no crank/no start
  211. IDM
  212. maxi-fuse #13 blows
  213. Ignition tumbler seems disconnected
  214. 95 powerstroke help
  215. 1995 7.3
  216. #8 fuse blowing
  217. Shift fork question
  218. Vacuum pump issue
  219. 1997 f250 straight axle swap
  220. What in the world caused this?
  221. Buying a used Fuel tank sensor
  222. help
  223. trouble steering right
  224. 97 7.3L keep quitting
  225. 1995 f250 quit suddenly now no start please help!!
  226. New to me 97 F350 CCLB
  227. 1995 7.3 ipr
  228. Rough idle, blue/gray smoke, loss of power
  229. Hard start, rough idle, low power, white smoke...please help!
  230. Trans/wiring issues
  231. Clutch pop when releasing pressure
  232. 97 f250 skipping and knocking
  233. HELP!!
  234. Ruff runing
  235. 1996 7.3 no start
  236. Battery drain, low voltage no crank
  237. I Want To Check Compression
  238. Ipr missing nut and spacer
  239. Oil in Fuel
  240. Gauge cluster not working
  241. Idle Drops Low When Trans Put In Gear
  242. Burning Oil Smell
  243. 1995 no start
  244. Changed Fuel Filter now won't start
  245. No blower
  246. Would you buy this?
  247. Long start after headlight change
  248. I’m on 96 7.3
  249. 1995 f350 Won't Crank
  250. New truck doesn't want to rev?