1994-1997 Power Stroke Technical Info [Archive] - Page 9 - PowerStrokeNation : Ford Powerstroke Diesel Forum

1994-1997 Power Stroke Technical Info


  1. Help!! Rebuilt 7.3l powerstroke starting issue when warm
  2. Back from the dead
  3. Shifts and bogs down at low speed
  4. 97 f250 HELP!!!!!
  5. Motor dumped all its oil now has delay in starting
  6. 97 f250 truck rolling in park
  7. Transmissions Interchangeable
  8. Headlights stopped working ?!
  9. 94.5 7and 8 misfire going blind
  10. 1996 no start after fuel filter
  11. Where to drain coolant.
  12. 1997 f350 intermediate steering shaft
  13. Possible HPOP Issue... I Think...
  14. Good how-to for oil cooler seals?
  15. New fan clutch will not disengage
  16. no running lights
  17. broken barb on fuel tank selector valve
  18. Starting issue click but no crank.
  19. Tranny swap
  20. Exhaust manifold bolt question
  21. 1995 fuel leak
  22. 7.3 zf5 unbearable rattle from bell housing area at idle
  23. New truck, auto trans question
  24. Quick brake question
  25. 1997 F-250 no "wait to start" light, good fuse
  26. Hard start up 7.3
  27. I know what is wrong, just don't know diesels enough to fix..
  28. 1996 7.3 manual shift rpm
  29. water leaking out onto drivers floor
  30. Newbe- power problem low speeds wont rev up
  31. Totally new to Power Strokes!
  32. Pop / clank noise
  33. 1995 F250 Powerstroke Oil Leaks off Inspection Cover
  34. Pop / clank noise
  35. 1997 F-250 7.3 bad under hood insulation, what's its purpose
  36. turbo help
  37. ABS/Brake issue & fuel gauge issue
  38. crew cab rear door and rocker panel replacment sheet metal?
  39. left side engine mount bracket
  40. Search hasn't helped enough, still isn't fixed
  41. Hard start
  42. 1997 7.3 small amount of oil in the coolant tank.
  43. No dash light no crank
  44. Looking for info on fordcummins obs crew cab on f550 chassis
  45. drive shaft differences?
  46. 1997 7.3 hard to start
  47. Sterling 10.25" issue.
  48. Weird stumble with cel. Then clears up
  49. 96 u-joint part numbers
  50. Will 5.4L E4OD fit my 7.3L?
  51. Introduction & work to be done
  52. Re seal fuel bowl or spend a bit more for the tightwad mod?
  53. Horsepower & Torque 97 7.3
  54. A rod fell from my engine... What is it?
  55. 97 Fuel/ Water Seperator Needed
  56. E4OD Problems
  57. Gutless
  58. Exhaust manifold leak
  59. 7.3 Hiccup at 2300 RPM
  60. 97 f350 turbo diesel cranks but won't start.
  61. Rear Diff Fill Plug Size
  62. rear drive shaft length
  63. Squeak when turning left
  64. Strange E-fuel Problem...need advice
  65. Maybe CPS ? Help
  66. fuel pressure question
  67. Rear main seal
  68. Keep blowing #9 Maxi fuse 96 F250???
  69. Leak at HPOP reservoir question.
  70. Signs of bad Mechanical Fuel Pump?
  71. Maybe somebody can give me some ideas 1996 7.3
  72. 7.3 blowing white smoke like a freight train. Injectors???
  73. Ac switch pigtail
  74. Need help now!
  75. Turning issues and death wobble
  76. Truck stumbles while driving and then dies
  77. Stock injector question
  78. what length drive shaft do I need?
  79. pcm replacement
  80. Electrical demon! Need help finding her
  81. Coolant lines and tranny lines
  82. diagnostics
  83. Coolant recovery tank
  84. 95 sway bar
  85. truck idleing rough and missing
  86. Power loss/ boost leak confusion
  87. CPS issues. Help please!
  88. HELP!!!!! 97 F250 7.3
  89. Cruise control
  90. Fuel leak frustration
  91. 1994 F250 7.3L Replaced Starter (Starter Not Engaging)
  92. Help no start 97 powerstroke
  93. noise when shifting
  94. plezz help oil leak
  95. P1391 P1393 codes
  96. Unplugged ebpv engaging
  97. E40d output shaft seal part#
  98. Intercooler and ccv mod
  99. Fuel bleeding down
  100. Blue interior Paint
  101. Another zf5 fluid thread
  102. Another power window question 97 CCSB
  103. Serious starter problems
  104. Problems , need help please
  105. Newbie..1997 F350 Crew Cab Dually, 7.3 Powerstroke HELP!!!!
  106. Water came out exhaust on cold start help???
  107. Intermittent CEL and Shifting Issue
  108. Tranny keeps kicking out of overdrive
  109. Question about my TW chip
  110. Cruise control for non stock cruise control
  111. Need help quick
  112. Stalls while driving, not CPS. Please help
  113. Self aligning 4x4 F-350
  114. Strange clicking sound
  115. ecu interchange
  116. Ecu reflash or replace
  117. p1212 can i get some wisdom
  118. 19.5s on a super duty 10 lug
  119. MAP sensor issue
  120. Rear main seal
  121. obs electrical issue
  122. Oil leak at dipstick tube
  123. overdrive issue
  124. Radiator support mounts
  125. Most miles on a 7.3??
  126. Engine fumbles and wont go above 2500 rpm
  127. Wiring diagram for cruise control circuit?
  128. Edge cool down timer help
  129. 1997 F 250 7.3 automatic, questions
  130. Help with apcm
  131. Cruise control issue
  132. Aux idle controller
  133. 1997 E350 ps PCM
  134. Hpop diffuser crossover question
  135. Question regarding 96 7.3 first start up after tear down
  136. Engine compartment.
  137. "new" alt truck runs worse
  138. Bad compressor wheel
  139. Looking for radiator support mounts.
  140. 95 350 7.3L --Should I buy?
  141. fuel bowl pressure low
  142. Lugs when shifting
  143. ZF5 and fluid
  144. steering wheel off center
  145. Fuel gauge over night craziness
  146. Welding on my truck
  147. low and high fuel pressure
  148. blue smoke when cold.
  149. Brake light wire
  150. fuel leak
  151. Weird e4od transmission issue??
  152. bed tweaked on driver side
  153. Oil/Filter: Amsoil vs Delo vs T6
  154. Sudden Rough Idle and Miss, Aluminum in Oil
  155. Bad IPR?
  156. New to me 7.3
  157. Trying to decide
  158. Not sure what's wrong
  159. Ebv exhaust brake and back pressure gauge
  160. Anti seize on turbo install
  161. IPR questions
  162. Feels like a Mis fire
  163. Replacing a 97 California emissions fuel pump
  164. Busted Metal Fuel Line
  165. Pulled some codes
  166. Is this too much turbo oil blowby ? (pictures)
  167. dana 60 axle question
  168. Unsuspected Rust
  169. Computer error message/issues on pto controller
  170. No start problem
  171. I've got a good one for everyone
  172. Powerstroke 7.3 problem
  173. Starter problems / idea's?
  174. Zf5 s42
  175. Cruise Control
  176. Egt probe in the top of the manifold ?
  177. How tight do you torque injector hold-downs?
  178. lope black smoke no cel
  179. Brake Line
  180. Core support
  181. Smoke out dipstick
  182. Odomoter question
  183. camshaft oil leak
  184. Transmission running to hot
  185. motor swap help
  186. E fuel help
  187. Scratching my head a/c issue
  188. tcase rebuild questions
  189. Need Help with 1997 f350 7.3 dump
  190. Steering wheel wire diagram
  191. Cam position sensor
  192. Child Locks?
  193. Strange, instant fuel pressure issue with LOTS of white smoke
  194. Lopping on cold start no power won't rev past 2000 rpm
  195. Dana 60 swap squeak after install
  196. Marine Fuel Tank Vent
  197. SD electric vacuum boost conversion
  198. 7.3 chip question
  199. Wont go into RKE Programming Mode
  200. '96 fuel gauge issue
  201. 95 7.3 not shifting/ no speedo
  202. OBS sway bars
  203. Tie-Rods, Drag Link Issue
  204. a couple of questions
  205. Sending unit
  206. Low mileage use, amsoil, how often to change oil?
  207. Still shifting weird no dtcs
  208. Bought another OBS 7.3, have a few questions
  209. shuts off and wont start
  210. glow plugs and injectors
  211. Stupid question but confused
  212. Truck gushing coolant after break down
  213. ABS light and strange shifting
  214. Radiator support project
  215. how to add the keypad to my 97 crew cab with factory rke already equipped
  216. Rear Power Locks
  217. gear shift indicator broke
  218. Howd i do?
  219. Best way to stop thermostat housing leak?
  220. First post
  221. Thoughts on this truck
  222. Radiator hose kit for a 1995 F350
  223. A few issues I cant seem to figure out.
  224. How to check PCM before installing PHP Hydra?
  225. in the process of pullin my 7.3
  226. Different water pump for '94 and '95?
  227. Ever hear of Loctite on a fan clutch???
  228. zf5 swap need help!
  229. Leak in the valley
  230. Temp sensor issues
  231. 95 Brake lights stay on sometimes!
  232. My Efuel buildup.
  233. load range
  234. Fuel line question
  235. Injector Driver Question
  236. smoke on startup
  237. High mileage??
  238. Acceleration Problems
  239. Billowing white smoke on initial start
  240. leaky hpop
  241. IPR Duty % 45+ @ idle
  242. Front axle question
  243. more electrical issues that have me stumped after install of TW chip help please!!!!
  244. 95 rough idle
  245. Looking for part search help. OBS
  246. Need help with ebp, tourque lock control boxes
  247. Need help! Efuel on california truck problems!
  248. need some info
  249. still no cruise control
  250. Need help with no start / long crank fire (sometimes)