1994-1997 Power Stroke Technical Info [Archive] - Page 2 - PowerStrokeNation : Ford Powerstroke Diesel Forum

1994-1997 Power Stroke Technical Info


  1. 96 transfer case
  2. Stuff to rob from a E99 for a OBS
  3. Up pipe HELP for 1997 7.3
  4. 95 hpop res
  5. No Windows! Help!
  6. Wanted: OBS Grille
  7. Possible Bad Fuel?
  8. Coolant pouring out of turbo
  9. Dead end need help
  10. 1994.5 7.3 Direct Injection Turbo Diesel Wait To Start light blinking No Start
  11. No horn or cruise
  12. White smoke at startup and unburned diesel smell
  13. Hard start when left sitting, once warm, starts instantly
  14. No start no smoke
  15. Would a loose tranny pan cause tranny to go into "limp mode"?
  16. E4od slipping in reverse
  17. O/D Light Flashing, Hard Shifts, new TC
  18. O/D LIGHT FLASHING ON HOT DAYS
  19. Surge/rough running an issue
  20. 97 7.3 power steering bracket help please!
  21. Was running fine, shut off now no start
  22. Dash panel question
  23. Hpop resivour
  24. Rough idle loud knocking
  25. Exhaust Back Pressure Valve.. Does it work?
  26. Need help identifying part: Leak at trans dipstick adapter tube?
  27. E40D Transmission codes
  28. hpop 95
  29. 1996 7.3 Bone Stock - Crank No Start
  30. Overdrive light flashing
  31. losing boost out of turbo actuator rod!?
  32. Radiator support mount hardware
  33. Fuel Bowl Heater Plug
  34. Fuel injector o-rings ruined by AMSOIL - any experience with this?
  35. "bad regulator on new alt and batteries"
  36. E4OD trans issues, Please Help
  37. 97 PSD Crank/No Start - Stumped
  38. 1997 7.3 powerstroke slight surge at idle, idles ro ugh, and runs rough HELP PLEASE!!!!!!
  39. E-Fuel Cold weather prep
  40. Valve cover bolt sheared? Help needed!
  41. Lower radiator hose does not get warm
  42. WIF sensor part number?
  43. Fuel Pump Lines
  44. Excessive rattle when stopping and turning
  45. Wiring Harness Under Steering Column
  46. 96 f250 steering column help
  47. Newb with a fuel leak in the valley
  48. New member with Tech Questions after Turbo rebuild and new Injector O-rings install...
  49. HPOP on 94.5?
  50. Education on turbos.
  51. Help, 94 7.3, no tach, trans acting up
  52. need Help with hard brake pedal 7.3
  53. Fuel Level Sensor Part Number
  54. Like a moron I ran my OBS out of fuel- need advice on bleeding out the air.
  55. Saginaw Swap
  56. 7.3 runs rough at start then smooths out warm
  57. Need Help Finding 1Ē Rubber Hose
  58. Engine removal
  59. Any pictures of supercab interior stripped down?
  60. Canít Remove Up-Pipe
  61. Fuel Pump Replace
  62. Day with an OBS
  63. I bought a 7.3L! 1996 f-250 with 211k miles
  64. Motor has difficulty revving over 2500rpm
  65. Fuel system issue
  66. Speedo recalibrate
  67. 1997 F250 Multiple Issues Need Advice
  68. Dash harness and cluster for Powerstroke swap
  69. 97 f250 stumle at 2500 RPM
  70. Help with a 97 f250 7.3
  71. Help! Chance to buy this 97 f250 7.3 4x4
  72. 7.3 Dies on first startup runs fine after
  73. 6R140 to 7.3?
  74. Blow-By
  75. Missing in one of the front pass side cylinders
  76. No tach
  77. HPOP failing 7.3?
  78. Bad Turbo?
  79. Bent axle housing
  80. Year later . My 1997 crew cab dually five speed
  81. New door hinges
  82. 7.3 starts great runs rough when warm
  83. 7.3 no start.
  84. Air Duct leading to intake?
  85. Idle up and down just sitting?
  86. '96 F250 7.3L: No Cruise Control.
  87. HARD LOPE sound HELP
  88. 97 obs f250HD, need complete front hub
  89. Using MT250p for Trans Codes
  90. Fuse Keeps Blowing When Running Rear Tank
  91. Wired up license light, ABS light kicks on
  92. Fuel Pressure Regulator Problem
  93. 1996 with chugging bucking issue
  94. 1995 Fsuperduty ignition problems
  95. 97 F250 Bucking/stalling when engine is hot
  96. 96 F350, 5 spd man, no pulling power
  97. 95 7.3 crank won’t start, starts with ether, dies at idle
  98. Clutch and oil pan needs replaced. Pull motor and trans together? obs 7.3
  99. Torque converter locker for 1st and 2nd 4EOD
  100. 1995 7.3 Powerstroke Turbo - random no start
  101. low boost
  102. 97 f250 lack of power
  103. Loss of power 95 f350
  104. 'Brake' Warning Light Always on - What'd I Miss?
  105. 97 OBS Blend Door
  106. E4od help
  107. Cruise control problem
  108. 97 7.3 e4od torque converter unlocks every now and then
  109. 1997 white smoke startup and stumble
  110. Hydroboost hoses
  111. Stock up pipes stainless?
  112. NAW6 DPC-202 PCM -- Advice Needed
  113. Fresh rebuilt 7.3 no start
  114. Power window help
  115. Battery terminals always corroding
  116. Up-pipes, tubo, and what else?
  117. Coolant Loss
  118. Are these numbers acceptable
  119. Fluctuating idle when hot
  120. Plastic front tank size
  121. Snap crackle pop goes the tranny
  122. 7 of 8 injectors stamped reman?
  123. Misfire and shaking?
  124. 96 350 died while driving, #22 maxi fuse blown
  125. F350 fender height
  126. ProVent 200 Questions
  127. early 95 intermittent stumble/ running rough
  128. No horn or cruise control
  129. Glow plugs and rocker arm question 7.3 DIT
  130. AC From Decrost Only
  131. Loss of Power and Died. HELP!!!
  132. Zf5 clutch squeal when cold, goes away when clutch lightly pressed
  133. Low Power, Low Boost & No Timing
  134. P1531 and Cylinder Contribution Test, etc.
  135. 97 F350 7.3 ZF5 2WD front end interchange info
  136. 97 F350 tensioner puzzle
  137. New to Powerstroke
  138. Lope on start up even in neutral.
  139. 97 7.3 rebuild questions
  140. Losing 1gallon of oil per day
  141. 1997 Crew Cab Power Window Help
  142. In need of Help. Oil Filter housing threads damaged
  143. 1997 7.3l overheating
  144. WTS light only comes on for about 2 seconds
  145. 96 Reg cab 4x4 7.3 build...
  146. No PCM or WTS light after sitting 3 years
  147. 97 7.3 compression test ran 640 psi on cylinder 6
  148. 97 7.3 started knocking and rolling a gray smoke
  149. 1995 TPS bad no throttle response please help
  150. 1994 power stroke CEL and no power
  151. Need help. Towing questions.
  152. 1997 Powertrain problem.
  153. Probably the same old questions
  154. Stumbled, died and will not restart
  155. 95 long start.
  156. Trouble with pids using Torque Pro on 1995 PSD
  157. 7.3 hard start
  158. No start!!! New turbo, injector o-rings, fuel pump, ipr and icp
  159. Machining injectors
  160. 95 7.3 no start
  161. 95 7.3 no start, everything looks ok on scanner
  162. 1997 7.3 Fluctuating Fuel Pressure
  163. Clutch issues
  164. WANTED: Oil Dipstick Tube Bracket
  165. replacing gauge cluster lights
  166. Truck dies constantly when hot
  167. Rough idle at startup and cuts out when attempting to accelerate
  168. Switched Power Location for Efuel controller
  169. Gear selector stuck in gear and wont shift.
  170. 97 f250 won’t shift out of second
  171. 1995 7.3 head bolts
  172. What yr 7.3 is best ???
  173. No HPOP pressure
  174. Fenderwell Heights
  175. cooling system maintenace to do list
  176. Truck cuts out when floored
  177. 7.3 motor swap
  178. 97 7.3 surging while driving
  179. 7.3 issues
  180. Ron’s turbo service
  181. missing under load
  182. 1997 F350 - 150k miles
  183. New to me 7.3 concerns?
  184. Codes
  185. SD 7.3 part to OBS interchangeability
  186. 7.3 piston gap
  187. 1997 Powerstoke
  188. IDM: quick question.
  189. Obs hpop and fuel pump
  190. Glow Plug Timer?
  191. What is this?
  192. Coolant flush, what coolant to put back in
  193. TP-38 Turbo Experts. Turbo damage
  194. 97 Powerstroke hard starting this winter now no start
  195. Ford E Locker retrofit?
  196. 1994 7.3 f250
  197. High pressure oil rail End plug replacement
  198. Rear axle codes and Dana 60 swap
  199. new caliper piston sticking f super duty 97
  200. Injector wire harness rebuild...
  201. third brake light, dome light, door unlock not working.
  202. Stock turbo rebuild problem
  203. Fuel leak
  204. twin beam suspension
  205. 1994.5 PSD fuel filter light on then stalls
  206. Dome and Cargo Light Stay On
  207. 1997 rebuild
  208. Steering wheel very tight after column rebuild
  209. Obs intercooler pipes
  210. Can anyone tell me what this spyder is off of?
  211. 1995 psd wot skip
  212. Changed uppipes,bluish-grey smoke behind turbo
  213. Need new pcm
  214. New Alternator and 2gauge wire, less voltage
  215. Shredding serpentine belts.
  216. three CPS sensors in 5 years
  217. Tapping noise under load and CCT
  218. E4od Front Pump Bushing Install
  219. 1997 f-350 exhaust manifold replacement
  220. Bad injector or injector o-rings?
  221. 97 PSD dies when hot, then starts again
  222. obs powerstroke cab cracking under driver door
  223. Fuel bowl delete
  224. Front disk breaks locked up
  225. PCM with loose banks chip
  226. The dreaded Idle blip?!?
  227. 97 PSD 7.3 Died Now No Start
  228. Power steering leak
  229. HPOP going bad?
  230. 1994.5 can you use a scan tool or a tuner ?
  231. Transmission Dipstick Tube pinhole leak
  232. Truck Stalling, I'm Stumped
  233. 96 ZF5-how much ATF for a top fill
  234. 97 E4OD and tach problems
  235. Are units
  236. 1997 7.3L F250 Possible bad PCM?
  237. 1997 F250 Powerstroke 7.3L. Possible bad PCM?
  238. Ebps/Map
  239. Fuel Gauge Issue!
  240. Turbo rebuilding problem need advice
  241. Truck smokes really bad when first started up.
  242. New UVCHs leaking oil
  243. fuel bowl reg line
  244. Did I toast my wiper motor
  245. Please Help!! Starts and dies
  246. rear axle hose popped off
  247. No headlight at all.
  248. Fuel bowl return hard love question
  249. Catalytic Converter
  250. 1997 F350 Ball Joints