05 f350 truck will die while coming to a stop then have difficulty starting - PowerStrokeNation : Ford Powerstroke Diesel Forum
 2Likes
  • 1 Post By River Red Neck
  • 1 Post By bismic1
 
LinkBack Thread Tools Display Modes
post #1 of 9 (permalink) Old 10-22-2019, 04:42 PM Thread Starter
PSN Newb
 
Join Date: Oct 2019
Posts: 4
05 f350 truck will die while coming to a stop then have difficulty starting

Here's my story, I had injector 6 go down, had to drive it for a week till I could get another injector, changed it out, truck fired up and ran awesome again......for a couple days, then I was driving into a parking lot and the truck died, i cranked it over and it took a few tries to get it to fire, when it did it ran great. It did the same thing a couple of more times over the next couple days, each time was the same, I was coming to a stop and it would die. This morning I started my truck, it fired up good, after about ten minutes of warm up, it died and I couldn't get it to start up again for about 15 mins, i had it plugged in because it is getting below 0c at night, the block heater and the glow plugs work just fine. I'm baffled as this has never happened until recently. Any help or in-site would be much appreciated
River Red Neck is offline  
Sponsored Links
Advertisement
 
post #2 of 9 (permalink) Old 10-22-2019, 05:18 PM
EA - Eggfarts Anonymous!
 
Turd-250's Avatar
 
Join Date: May 2013
Location: Red Dirt Country
Posts: 18,697
Re: 05 f350 truck will die while coming to a stop then have difficulty starting

welcome to the forum!
The only thing touched was the #6 injector right? might be the oring leaking off oil. Sis you install it or did a shop?


To view links or images in signatures your post count must be 10 or greater. You currently have 0 posts.


To view links or images in signatures your post count must be 10 or greater. You currently have 0 posts.


To view links or images in signatures your post count must be 10 or greater. You currently have 0 posts.


"Farts are like a good bourbon, add a small touch of water to bring out the excellence."
Turd-250 is offline  
post #3 of 9 (permalink) Old 10-22-2019, 05:19 PM
EA - Eggfarts Anonymous!
 
Turd-250's Avatar
 
Join Date: May 2013
Location: Red Dirt Country
Posts: 18,697
Re: 05 f350 truck will die while coming to a stop then have difficulty starting

to confirm this, you can watch the ICP pressure with a monitor or scanner. good thing to have on hand with the wonderful 6.0 anyways lol


To view links or images in signatures your post count must be 10 or greater. You currently have 0 posts.


To view links or images in signatures your post count must be 10 or greater. You currently have 0 posts.


To view links or images in signatures your post count must be 10 or greater. You currently have 0 posts.


"Farts are like a good bourbon, add a small touch of water to bring out the excellence."
Turd-250 is offline  
 
post #4 of 9 (permalink) Old 10-22-2019, 06:36 PM Thread Starter
PSN Newb
 
Join Date: Oct 2019
Posts: 4
Thanks for the help, I installed the injector myself, I have done lots of injectors in my truck as well as friends trucks as well, would ICP cause these issues? Would me having to run the truck with the fouled injector cause my ICP or IPR to fail?
Turd-250 likes this.
River Red Neck is offline  
post #5 of 9 (permalink) Old 10-22-2019, 06:58 PM
"resident smarty pants"
 
Join Date: Apr 2008
Posts: 3,941
Re: 05 f350 truck will die while coming to a stop then have difficulty starting

Fouled injectors aren't going to cause a no-start when hot.

Do you still have the original dummy plug? How about the original discharge fitting (STC) on the HPOP?
Turd-250 likes this.

Mark
06 F250 CC SB FX4 Lariat;ARPs OEM gaskets;Banks exhaust;DynaTrac Balljoints;RACCCV6000;Updated HPOP fitting;JimmiJammers;Ravelco;plugs&standpipes;Fumo to;Harpooned;Quadzilla XZT Fuel Press;Blue spring;DashDAQ;PHP_FICM; RiffRaff boots;DCPower270A XP;Inverter;Rancho7000's;BPD EGR cooler;BPD WaterPump;SCT Matts SRL+;ELC Ultra w/ filter;SynchroMax
bismic1 is offline  
post #6 of 9 (permalink) Old 10-22-2019, 07:34 PM Thread Starter
PSN Newb
 
Join Date: Oct 2019
Posts: 4
Yes and yes
River Red Neck is offline  
post #7 of 9 (permalink) Old 10-22-2019, 07:53 PM
"resident smarty pants"
 
Join Date: Apr 2008
Posts: 3,941
Re: 05 f350 truck will die while coming to a stop then have difficulty starting

Watch ICP pressure (psi), ICP volts, and IPR % duty cycle. Be prepared to do an air test of the high pressure oil system.

Leaking (original) dummy plugs are the most common leak point in an 05+ engine. The original standpipes have been upgraded also. You will probably need to install both of these upgrades in both oil rails.

The STC fitting fails frequently also. You have to access the HPOP for this install. It is a bit more involved, but the thing with it is that sometimes it fails catastrophically and if it does, it can crack the rear cover. The upgraded one-piece fitting resolves this issue.

Mark
06 F250 CC SB FX4 Lariat;ARPs OEM gaskets;Banks exhaust;DynaTrac Balljoints;RACCCV6000;Updated HPOP fitting;JimmiJammers;Ravelco;plugs&standpipes;Fumo to;Harpooned;Quadzilla XZT Fuel Press;Blue spring;DashDAQ;PHP_FICM; RiffRaff boots;DCPower270A XP;Inverter;Rancho7000's;BPD EGR cooler;BPD WaterPump;SCT Matts SRL+;ELC Ultra w/ filter;SynchroMax
bismic1 is offline  
post #8 of 9 (permalink) Old 10-22-2019, 08:21 PM Thread Starter
PSN Newb
 
Join Date: Oct 2019
Posts: 4
Thanks for the great info, I will do the dummy plug and stand pipe upgrade and STC fitting, I appreciate your help
River Red Neck is offline  
post #9 of 9 (permalink) Old 10-23-2019, 12:04 AM
"resident smarty pants"
 
Join Date: Apr 2008
Posts: 3,941
Re: 05 f350 truck will die while coming to a stop then have difficulty starting

If work has recently been done on the injectors (or the oil rail removed), you can have a leak on them as well. That is why an air test is important.

Mark
06 F250 CC SB FX4 Lariat;ARPs OEM gaskets;Banks exhaust;DynaTrac Balljoints;RACCCV6000;Updated HPOP fitting;JimmiJammers;Ravelco;plugs&standpipes;Fumo to;Harpooned;Quadzilla XZT Fuel Press;Blue spring;DashDAQ;PHP_FICM; RiffRaff boots;DCPower270A XP;Inverter;Rancho7000's;BPD EGR cooler;BPD WaterPump;SCT Matts SRL+;ELC Ultra w/ filter;SynchroMax
bismic1 is offline  
Reply

Quick Reply
Message:
Options

Register Now



In order to be able to post messages on the PowerStrokeNation : Ford Powerstroke Diesel Forum forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.

User Name:
Password
Please enter a password for your user account. Note that passwords are case-sensitive.

Password:


Confirm Password:
Email Address
Please enter a valid email address for yourself.

Email Address:
OR

Log-in










Thread Tools
Show Printable Version Show Printable Version
Email this Page Email this Page
Display Modes
Linear Mode Linear Mode



Posting Rules  
You may post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are On
Pingbacks are On
Refbacks are On

 
For the best viewing experience please update your browser to Google Chrome