How long to purge air??? - PowerStrokeNation : Ford Powerstroke Diesel Forum
 
LinkBack Thread Tools Display Modes
post #1 of 8 (permalink) Old 01-21-2012, 06:06 PM Thread Starter
PSN Local
 
deathwishracer's Avatar
 
Join Date: Nov 2009
Location: Yadkinville, N.C.
Posts: 135
How long to purge air???

So I have replaced injectors, stc fitting, standpipes, dummy plugs, ipr, and icp sensor, and batteries. I had some issues throughout this repair, but finally she fired. Starts fine, hot or cold. Still seems to have a slight shuttter at part throttle. Could it still have air after 20 mile test drive? Also, still set light one time for icp circuit low. Don't have the scanner right now to monitor pressure during drive. Could air be causing this? 2006 6.0, stock.

00 drw,auto,6.0 cooler,tymar,overboost annihilator,4 inch exhaust,ITP intank mod,GT38R,DPTuner F5(60tow,80econo,140 extreme),stage 2's,diy fuel system rr,adrenaline,airbags,Katzkins leather seats,A-pillar gauges,05' front end,HID headlights,cowl induction hood,all lights are l.e.d., 24 inch alcoas
deathwishracer is offline  
Sponsored Links
Advertisement
 
post #2 of 8 (permalink) Old 01-21-2012, 10:38 PM
PSN Newb
 
Join Date: Oct 2011
Posts: 10
Re: How long to purge air???

whats the code number? and when you test drove it did you drive it hard or just put around?
6.0lover/hater is offline  
post #3 of 8 (permalink) Old 01-21-2012, 11:07 PM
PSN Veteran
 
Join Date: Apr 2008
Posts: 2,524
Re: How long to purge air???

you should do a series of 3-4 WOT runs (after the truck has warmed up) to fully purge the air out.

Mark
06 F250 CC SB FX4 Lariat;ARPs OEM gaskets;Banks exhaust;DynaTrac Balljoints;RACCCV6000;Updated HPOP fitting;JimmiJammers;Ravelco;plugs&standpipes;Fumo to;Harpooned;Quadzilla XZT Fuel Press;Blue spring;DashDAQ;PHP_FICM; RiffRaff boots;DCPower270A XP;Inverter;Rancho7000's;BPD EGR cooler;BPD WaterPump;SCT Matts SRL+;ELC Ultra w/ filter;SynchroMax
bismic1 is offline  
post #4 of 8 (permalink) Old 01-22-2012, 03:22 AM
Hood Rich
 
CTC DEEZUL's Avatar
 
Join Date: Sep 2010
Location: NW Indiana
Posts: 2,873
Send a message via AIM to CTC DEEZUL
Re: How long to purge air???

ford spec is 12 wot blasts under load..... i just drive the truck for 30 minutes, some wot blasts to 70 mph than cruising...

NWI Coal Rollers Association

Local 444- Rolling Coal Teamsters
via Beans Toonz
DI SS Up-Pipe
GTP38R
CTC DEEZUL is offline  
post #5 of 8 (permalink) Old 01-22-2012, 03:44 AM
PSN Veteran
 
Join Date: Apr 2008
Posts: 2,524
Re: How long to purge air???

Couldn't recall the number!!! Was way off - thanks CTC

Mark
06 F250 CC SB FX4 Lariat;ARPs OEM gaskets;Banks exhaust;DynaTrac Balljoints;RACCCV6000;Updated HPOP fitting;JimmiJammers;Ravelco;plugs&standpipes;Fumo to;Harpooned;Quadzilla XZT Fuel Press;Blue spring;DashDAQ;PHP_FICM; RiffRaff boots;DCPower270A XP;Inverter;Rancho7000's;BPD EGR cooler;BPD WaterPump;SCT Matts SRL+;ELC Ultra w/ filter;SynchroMax
bismic1 is offline  
post #6 of 8 (permalink) Old 01-22-2012, 05:19 PM Thread Starter
PSN Local
 
deathwishracer's Avatar
 
Join Date: Nov 2009
Location: Yadkinville, N.C.
Posts: 135
Re: How long to purge air???

Yeah, didn't have that much time, or wot runs, so maybe still air. Would that cause a low icp circuit light?

00 drw,auto,6.0 cooler,tymar,overboost annihilator,4 inch exhaust,ITP intank mod,GT38R,DPTuner F5(60tow,80econo,140 extreme),stage 2's,diy fuel system rr,adrenaline,airbags,Katzkins leather seats,A-pillar gauges,05' front end,HID headlights,cowl induction hood,all lights are l.e.d., 24 inch alcoas
deathwishracer is offline  
post #7 of 8 (permalink) Old 01-27-2012, 10:14 PM Thread Starter
PSN Local
 
deathwishracer's Avatar
 
Join Date: Nov 2009
Location: Yadkinville, N.C.
Posts: 135
Re: How long to purge air???

Got about 250 miles on truck after all the repairs. Still shutters at part throttle, check engine light is on. I will try to get scanner, and take readings on a test drive. Without the info from test drive, does anyone have a shot in the dark about where to look first?

00 drw,auto,6.0 cooler,tymar,overboost annihilator,4 inch exhaust,ITP intank mod,GT38R,DPTuner F5(60tow,80econo,140 extreme),stage 2's,diy fuel system rr,adrenaline,airbags,Katzkins leather seats,A-pillar gauges,05' front end,HID headlights,cowl induction hood,all lights are l.e.d., 24 inch alcoas
deathwishracer is offline  
post #8 of 8 (permalink) Old 01-28-2012, 01:09 AM
PSN Veteran
 
Join Date: Apr 2008
Posts: 2,524
Re: How long to purge air???

We really would need to see the ICP readings and the corresponding IPR duty cycle readings.

Mark
06 F250 CC SB FX4 Lariat;ARPs OEM gaskets;Banks exhaust;DynaTrac Balljoints;RACCCV6000;Updated HPOP fitting;JimmiJammers;Ravelco;plugs&standpipes;Fumo to;Harpooned;Quadzilla XZT Fuel Press;Blue spring;DashDAQ;PHP_FICM; RiffRaff boots;DCPower270A XP;Inverter;Rancho7000's;BPD EGR cooler;BPD WaterPump;SCT Matts SRL+;ELC Ultra w/ filter;SynchroMax
bismic1 is offline  
Reply
Gear in this thread - Powered by O'Reilly Auto Parts

Quick Reply
Message:
Options

Register Now



In order to be able to post messages on the PowerStrokeNation : Ford Powerstroke Diesel Forum forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.

User Name:
Password
Please enter a password for your user account. Note that passwords are case-sensitive.

Password:


Confirm Password:
Email Address
Please enter a valid email address for yourself.

Email Address:
OR

Log-in









Human Verification

In order to verify that you are a human and not a spam bot, please enter the answer into the following box below based on the instructions contained in the graphic.



Thread Tools
Show Printable Version Show Printable Version
Email this Page Email this Page
Display Modes
Linear Mode Linear Mode



Posting Rules  
You may post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are On
Pingbacks are On
Refbacks are On

 
For the best viewing experience please update your browser to Google Chrome